Product ID:CD-6 CLEAR DISPERSANT, 20274-0015
MSDS Date:06/16/1995
FSC:7930
NIIN:00N054780
MSDS Number: CBCHW

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 714-821-2556

Cage: IO122

Telephone: 714-821-2290

Cage: 14668

MINERAL SPIRITS; (MIXED C8-C12 ALKALINE ISOMERS, N.O.S.)

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: 100%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HIGH VAP CONCS (> APPROX
1000 PPM) ARE IRRIT TO EYES & RESP TRACT, MAY CAUSE HDCH & DIZZ.
SKIN: LOW ORDER OF TOX. FREQUENT/PRLNG CONT MAY IRRITATE & CAUSE
DERM. EYES: SLIGHTLY IRRIT BUT DOES NOT INJURE EYE TISS. INGEST:
SML AMTS OF THIS PROD ASPIR INTO RESP SYS DURING INGEST/VOMIT MAY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CAUSE MILD TO SEV PULM INJURY, POSS
PROGRESSING TO DEATH. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:PERS W/PREEXISTING HLTH CNDTNS OF
DERM & RESP AILMENTS WILL NOTICE PHYSICAL RXNS WHEN EXPOSED TO SML
AMTS OF PROD/VAP. CONSULT THEIR TREATING MD FOR PROPER ACTION AFTER
EXPOS.

First Aid:EYES: FLUSH W/CLEAR WATER FOR AT LEAST 15 MIN/UNTIL IRRIT
SUBSIDES. IF IRRIT PERSISTS, CONT MD. SKIN: REMOVE CONTAM CLTHG.
WASH SKIN THORO W/SOAP & WATER. DO NOT REUSE CONTAM CLTHG UNTIL
SOLV HAVE BEE N REMOVED. INHAL: REMOVE TO FRESH AIR. CALL MD IMMED.
IF BRTHG IS IRREG/STOPPED, START RESUSCITATION IF TRAINED. ADMIN
OXYGEN IF AVAIL. INGEST: DILUTE CONTENTS OF STOM W/SEVERAL GLASSES
OF WATER. DO N OT INDUCE VOMIT. CALL MD IMMED.

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:1.2%
Upper Limits:9.6%
Extinguishing Media:USE WATER SPRAY TO COOL FIRE EXPOSED SURFACES AND
TO PROTECT PERSONNEL. USE FOAM OR DRY CHEMICAL TO EXTINGUISH FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. AVOID SPRAYING WATER DIRECTLY INTO STOR CONTRS DUE TO DANGER OF
BOILOVER. SHUT OFF "FUEL" TO FIRE. IF LEAK/SPILL HAS NOT IGNITED,
USE WATER SPRAY TO DISPERSE VAPS.
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:LAND SPILL: ELIM ALL IGNIT SOURCES. PVNT ADDNL
DISCHARGE OF MATL, IS POSS TO DO SO W/OUT HAZ. RECOVER FREE PROD BY
ADDING SAND, EARTH/OTHER SUITABLE ABSORB TO SPILLED LIQ. KEEP
NON-ESSENTIAL PERS AWAY . AVOID BRTHG VAPS. VENT CONFINED SPACES.
CLEAN UP ABSORB MATL & DISP OF PROPERLY. CONTINUE TO OBSERVE PREC
FOR VOLAT, COMBUST VAPS FROM ABSORBED MATL. PVNT LIQ FROM ENTERING
SEWERS, (SUP DAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:COMBUST LIQ, CAN FORM COMBUST MIX
AT/ABOVE FL PT. STATIC DISCHARGE, MATL CAN ACCUM STATIC CHARGES
WHICH CAN CAUSE INCENDIARY ELEC DISCHARGE.
Other Precautions:"EMPTY" CONTRS CONTAIN PROD RESIDUE (LIQ &/VAP) & CAN
BE DANGEROUS. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE SUCH CONTENTS TO HEAT, FLAME, SPARKS, STATIC
ELEC/OTHER SUCH SOURCE S OF IGNIT. THEY MAY EXPLODE & CAUSE
INJURY/DEATH. EMPTY CONTRS SHOULD BE COMPLETELY DRAINED & DISP OF
(OTHER INFO)

Respiratory Protection:NOT NEEDED WHEN USED AS INTENDED WITH CALCOMP
PRODUCTS. IN CONCENTRATIONS EXCEEDING THE RECOMMENDED SAFE EXPOSURE
LIMIT, SUCH AS DURING A MAJOR SPILL, USE A NIOSH/MSHA APPROVED
CHEMICAL CARTRIDGE RESP IRATOR EFFECTIVE FOR ORGANIC VAPORS.
Ventilation:NO SPEC VENT IS NEEDED WHEN USED AS INTENDED W/CALCOMP
PRODS. NORM OFFICE VENT CONFORMING TO AMERICAN SOCIETY OF HEATING,
REFRIGERATING & AIR (TOX INFO)
Protective Gloves:NITRILE OR NEOPRENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:SHOULD NOT BE NEEDED WHEN USED AS INTENDED
IN CALCOMP PRODS. WEAR CHEM RESIST APRON WHEN CLEANING MACHINES AS
REPLENISHERS MAY STAIN CLOTHING. ANSI APPROVED EMERGENCY EYEWASH
AND DELUGE SHOWER .
Work Hygienic Practices:KEEP CONTRS CLSD WHEN NOT IN USE. DO NOT SMOKE
WHEN USING PROD. MIN BRTHG VAP/MIST. USE W/ADEQ VENT. AVOID
PROLONGED OR REPEATED SKIN CONTACT. WHENEVER HANDLING CHEMICALS,
ALWAYS USE GOOD (TOX INFO)
Supplemental Safety and Health
SPEC GRAV: 0.75-0.82 @ 15.5C (60F) (H*2O=1). SPILL PROC:
WATERCOURSES/LOW AREAS. CNTN SPILLED LIQ W/SORBENT MATL. DO NOT USE
COMBUST MATL SUCH AS SAWDUST. RECOVER LGE AMTS BY PUMPING (USE
EXPLO-PROOF PUMP) OR W/SUITABLE ABSORB. CONSULT EXPERT ON DISP OF
RECOVERED MATL & ENSURE CONFORMITY TO LOC & FED DISP (OTHER INFO)

Boiling Pt:B.P. Text:>320F,>160C
Melt/Freeze Pt:M.P/F.P Text:<-76F,<-60C
Vapor Pres:2 @ 20C
Vapor Density:4.94
Spec Gravity:SUP DAT
Evaporation Rate & Reference:0.3 (N-BUTYL ACETATE=1)
Solubility in Water:<0.01
Appearance and Odor:WATER WHITE LIQUID, WITH FAINT ISOPARAFFINIC
HYDROCARBON ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.

Waste Disposal Methods:WASTE TONERS & REPLENISHERS ARE HAZ WASTES AS
DEFINED BY 40 CFR CHAPTER 1 (FLAMMABILITY). ASSURE CONFORMITY W/ALL
APPLIC FED, STATE & LOC REGS. WASTE TONERS & REPLENISHERS ARE
COMPATIBLE FOR DISP W/MO ST NON-HALOGENATED SOLV & PETRO BASED
OILS. CONT LICENSED HAZ WASTE DISP COMPANY/ENVIRON CTL AGENCY FOR
ASSIST. POSS DISP METH INCLUDES (OTHER INFO)

Toxicological Information:OTHER INFO: HUMAN HLTH RISKS WHICH MAY VARY
FROM PERSON TO PERSON. AS A PRECAUTION, EXPOSURE TO LIQUIDS,
VAPORS, MISTS, OR FUMES SHOULD BE MINIMIZED. VENT: CONDITIONING
ENGINEERS (ASHRAE) 1980 STDS IS ADEQ UNDER NORM CNDTNS OF USE.
UNDER SOME CNDTNS OF USE/COMBINATIONS OF EQUIP, OFFICE VENT MAY NOT
BE ADEQ. USERS SHOULD ASSURE THAT VENT IS SUFFICIENT TO PVNT
EXCEEDING EXPOS LIM. USERS SHOULD CONSU LT QUALIFIED VENT ENGINEER
AND/OR INDUSTRIAL HYGIENIST IF A CONCERN REGARDING EXPOSURE ARISES.
HYGIENE PRACT: PERSONAL HYGIENE PRACTICES, SUCH AS WASHING YOUR
HANDS AFTER USING PRODUCT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.